Product ID:ADHESIVE-CLEAR MIL-A-82484, TYPE I
MSDS Date:07/26/1994
FSC:8040
NIIN:00N071791
MSDS Number: CBPLM

SEAGRAVE COATINGS CORP

320 PATERSON PLANK RD
CARLSTADT, NJ 07072
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 201-933-1000

Preparer: MH

Cage: DO631

SEAGRAVE CORP TITANINE DIVISION

CARLSTADT, NJ 07072-2302 US

Telephone: 1-800-424-9300

Cage: 78767

22.0 @ 20C

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <20%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

33.0 @ 20C

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <25%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM/500STEL

74.9 @ 20C

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: <20%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

0.0 @ 20C

CAS: 9004-70-0

RTECS: QW0970000

Fraction By Weight: <20%

OSHA PEL N/K

ACGIH TLV: N/K

PHTHALIC ACID, BIS(2-ETHYLHEXYL)ESTER;

CAS: 117-81-7

RTECS: TI0350000

Fraction By Weight: <5%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

32.0 @ 20C

CAS: 64742-89-8

Fraction By Weight: <20%

OSHA PEL N/K

ACGIH TLV: N/K

5.41 LBS/GAL; 648 G/L

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: BRTHG OF HIGH CONCS MAY PRDCE
NARCOS. LIQ MAY CAUSE MINOR SKIN IRRIT & DEFINITE EYE IRRIT. CAUSES
NOSE & THROAT IRRIT. CAUSES EYE & SKIN IRRIT. RPTD & PRLNG OVEREXP
TO SOLV COULD CAUSE PERM BRA IN & NERV SYS DMG. INTENTIONAL MISUSE
BY DELIBERATELY CONCENTRATING & INHALING CONTENTS MAY BE (EFTS OF
OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: HARMFUL OR FATAL. TOLUENE APPEARS ON
THE NAVY LISTING OF OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS.
SEEK CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONALS CONCERNING
LATEST HAZARD LIST INF ORMATION AND SAFE HANDLING AND
EXPOSUREINFORMATION .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
MD. SKIN: FLUSH WITH WATER WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION. WASH CLOTHING
BEFORE REUSE. DESTROY SHOES. INGESTION: GET MEDICAL ATTENTION
IMMEDIATELY.

Flash Point Method:SCC
Flash Point:21.0F,-6.1C
Lower Limits:0.3%
Upper Limits:12.7%
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS. IF WATER IS USED,
FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. VAPS MAY
MIGRATE TO IGNIT SOURCE & CAUSE FLASH FIRE. ISOLATE FROM HEAT,
SPARKS, ELEC EQUIP, APPLIANCES, PILOT LIGHTS, FLAMES (SUP DAT)

Spill Release Procedures:IN CASE OF SPILLAGE, ABSORB WITH INERT
MATERIAL AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS
OF EPA AND OTHER LOCAL, STATE, AND FEDERAL AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS AND OPEN
FLAME. AVOID PROLONGED SKIN CONTACT. DO NOT BREATHE SPRAY MIST.
Other Precautions:STORE IN A COOL DRY AREA W/VENT SUITABLE FOR STORING
MATLS SHOWN IN INGREDIENTS SECTION. GROUND CONTRS WHILE POURING.
AVOID SPONTANEOUS COMBUST OF CONTAM RAGS/OTHER ORG MATLS. EMPTY
CONTRS MAY RETAIN HAZ PROPERTIES & CAN BE DANGEROUS.

Respiratory Protection:NISOH APPROVED RESP TYPES SUITABLE FOR MATLS IN
ING SECTION REC. APPRVD CHEM/MECH FILTERS REC WHEN VENT IS
RESTRICTED. DO NOT BREATHE (DUST, VAPS/SPRAY MIST). WEAR APPROP
RESP (NIOSH APPRVD) DURING & AFTER APPLICATION UNLESS AIR (SUP
DAT)
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA PEL/ACGIH'S (SUP DAT)
Protective Gloves:CHEMICAL-RESISTANT PLASTIC OR RUBBER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . AS REQUIRED TO AVOID WETTING CLTHG. USE PROT CREAMS (SUP
DAT)
Work Hygienic Practices:REMOVE & WASH CONTAM CLTHG BEFORE REUSE. AVOID
CONT W/EYES, SKIN, & CLTHG. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLO HAZ: OTHER SOURCES OF IGNIT. EXTREMELY FLAMM LIQ & VAP. VAPS MAY
CAUSE FLASH FIRE. RESP PROT: MONITORING RECORDS VAP/MIST LEVELS
BELOW APPLIC LIM. FOLLOW RESP MFR DIRECTIONS FOR USE. VENT: TLV L
IM. USE W/ADEQ VENT. OTHER PROT EQUIP: WHERE SKIN CONT IS LIKELY.

Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Appearance and Odor:LIQUID, WITH CHARACTERISTIC ODOR
Percent Volatiles by Volume:82.5

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OR OPEN FLAME.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
AND PROBABLY CARBON MONOXIDE.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.